Turbochef-technologies TurboChef User Manual Page 7
- Page / 94
- Table of contents
- BOOKMARKS
Rated. / 5. Based on customer reviews
i
INTRODUCTION
IMPORTANT SAFETY INSTRUCTIONS
Strictly adhere to the following safety precautions to reduce the risk of:
Burns
Electric shock
Fire
Injury
Damage to oven or property near oven
Exposure to excessive microwave energy
GENERAL SAFETY INFORMATION
Read all instructions before using the appliance.
Install or locate this appliance only in accordance with the provided installation instructions.
Some products such as whole eggs and sealed containers (e.g., closed glass jars) may explode and should not be
heated in this oven.
Use this appliance only for its intended use as described in this manual.
This appliance should be serviced only by qualified service personnel. Contact the nearest authorized service
facility for examination, repair, or adjustment.
Keep cord away from heated surfaces.
x
DO NOT
allow children to use this appliance.
x
DO NOT use corrosive chemicals or vapors in this appliance - it is not designed for industrial or laboratory use.
x
DO NOT operate this appliance if it has a damaged cord or plug, is not working properly, or has been damaged
or dropped. See
POWER CORD REPLACEMENT
, page ii.
x
DO NOT cover or block any openings on the appliance.
x
DO NOT store this appliance outdoors.
x
DO NOT
use this product near water (e.g., near a kitchen sink, in a wet basement, near a swimming pool).
x
DO NOT immerse cord or plug in water.
x
DO NOT let cord hang over the edge of table or counter.
x
DO NOT use a water jet for cleaning. See the maintenance section of this manual on page 5 for proper cleaning
procedures.
REDUCING FIRE RISK
Remove wire twist-ties from paper or plastic bags used to facilitate cooking in the oven.
If materials inside the oven ignite,
- Keep oven door closed
- Turn oven off
- Disconnect the power cord or shut off power at the fuse or circuit breaker panel
If smoke is observed, switch off or unplug the oven. Keep the door closed to stifle any flames.
x
DO NOT
use the cook cavity for storage purposes.
x
DO NOT
overcook food. Carefully attend the oven if paper, plastic, or other combustible materials are placed
inside the oven to facilitate cooking.
x
DO NOT leave paper products, cooking utensils, or food in the cavity when not in use.
SAVE THESE INSTRUCTIONS
- TurboChef Service Manual 1
- For further information call: 2
- +1 214.379.6000 2
- NEVER attempt to 3
- Table of Contents 4
- IMPORTANT SAFETY INSTRUCTIONS 7
- GENERAL SAFETY INFORMATION 7
- REDUCING FIRE RISK 7
- EXCESSIVE MICROWAVE ENERGY 8
- GROUNDING INSTRUCTIONS 8
- POWER CORD REPLACEMENT 8
- 1 year parts and labor 10
- VAC, 60 Hz, 1 phase 10
- 4” (102 mm) adjustable legs 10
- 304 stainless steel line 10
- POWER INPUT 11
- TURBO / +1 214.379.6000 13
- 1 2 3 4 5 14
- Theory of Operation 15
- THEORY OF OPERATION 16
- CONTROL SYSTEM 16
- MICROWAVE SYSTEM 16
- CONVECTION SYSTEM 16
- BOTTOM IR AND CCV 16
- Fault Codes 19
- TO VIEW FAULT CODES 20
- FAULT CODE DEFINITIONS 20
- FAULT CODES 21
- The Control System 22
- CONTROL 23
- TEST MODE 24
- TEST FUNCTION OPTIONS 25
- W) status indicator is not 26
- DIAGNOSTIC MODE 26
- (CCSP) 26
- THE CONTROL SYSTEM 27
- FIGURE 15: Done Screen 28
- CONTROL SYSTEM PANEL PARTS 30
- ISSUE RESOLUTION 31
- 800.90TURBO 33
- The Microwave System 34
- MONITOR CIRCUIT DESCRIPTION 35
- MICROWAVE SYSTEM PARTS 36
- THE MICROWAVE SYSTEM 37
- MICROWAVE SYSTEM COMPONENTS 38
- WAVE GUIDE COVER REPLACEMENT 39
- WAVE GUIDE REPLACEMENT 40
- REPLACEMENT 40
- FIGURE 24: High Voltage Diode 42
- FIGURE 25: Magnetron 42
- The Oven Door 47
- OVEN DOOR PARTS 48
- ADJUSTING THE OVEN DOOR 49
- ADJUSTMENTS AND PARTS 50
- MONITOR SAFETY SWITCH PARTS 51
- = 0.020” 51
- Old Switch Setup 52
- New Switch Setup 53
- FIGURE 35: Oven Door Assembly 55
- PART TORQUE 56
- SCREW TORQUE CHART 56
- The Convection Circuit 58
- CONVECTION CIRCUIT COMPONENTS 59
- THE CONVECTION CIRCUIT 60
- IR Element and Catalytic 63
- Converter 63
- COMPONENTS 64
- Schematics and Schematic 66
- Components 66
- SCHEMATIC PARTS 67
- TEST POINT LOCATIONS 67
- I/O BOARD SCHEMATIC 68
- 41: NGC (Tornado) Schematic 69
- NGC (UK) SCHEMATIC 70
- 43: NGCEW (Tornado) Schematic 71
- 44: NGCED (Tornado) Schematic 72
- NGC (BRAZIL) SCHEMATIC 73
- Service Parts and 74
- Illustrations 74
- FILAMENT AND 79
- HIGH VOLTAGE 79
- TERMINALS 79
- APPLY HI-TEMP 81
- GREASE TO AREA 81
- FIGURE 35: OVEN DOOR ASSEMBLY 83
- TURBO or +1 214-379-6000 85
- Comprehensive Part List 89
- ITEM DESCRIPTION 90
- +1 214-379-6000 94
Related products and manuals for Microwaves Turbochef-technologies TurboChef
(34 pages)© 2020, manymanuals.com. All rights reserved. | 0.086 s |
Manymanuals.com
Manymanuals.de
Manymanuals.fr
Manymanuals.it
Manymanuals.pl
Manymanuals.cz
Manymanuals.es
Manymanuals-pt.com
Comments to this Manuals